Snippet about petrol storage and how quick it spoils,

[NorthernRaider]

Snippet about petrol storage and how quick it spoils, The Aussie branches of Shell, BP etc are a lot more forthcoming with info for the public than our own domestic companies.

NR



According to Shell’s Technical Advice Centre Manager, Warren
Scott, you can generally store fuel in a sealed container for around
six months before it starts to deteriorate. This assumes it’s kept
relatively cool and away from direct sunlight.

“But if the container is not properly sealed or it’s repeatedly opened,
[fuel] will start to evaporate and you lose some of the light
components in the fuel,” Mr Warren says.

Those light components include highly important butane. As these
components are lost, the fuel loses its volatility. Mr Warren says this
makes the car difficult to start.

In warm conditions, fuel is especially prone to oxidisation which
causes lacquer and gums to form. As a result, the fuel turns dark in
colour, loses its clarity and smells like paint stripper.

Gary Whitfield, Senior Fuel Chemist at BP Australia says that in the
right conditions, fuel can last up to 12 months. But once the container
is opened, the fuel will start to degrade.

“Once the seal is broken, a vapour space is formed in the container and
the fuel will start to deteriorate more rapidly,” he says.

Okay, so what about fuel that’s left in your car’s tank for a long period of time?

Mr Whitfield claims fuel in a car’s tank can last for up to four weeks
before it becomes considerably denser. When this happens, the engine is
effectively over-fuelled (without any change in injector pulse-width)
and there’s an increased chance of carbon deposition onto spark plugs and inside the combustion chamber. This can cause driveability problems such as stutters and misses.

“Regular unleaded fuel will lose a small amount of octane over time but
in our low-sulphur and high detergent Ultimate fuel it might increase
very slightly. It might increase 1 RON in four weeks – but it’s not
something I’d bother chasing,” he says.

“Keep in mind that typical variation in BP Ultimate is 98 – 100 RON while normal unleaded ranges between 91 – 93 RON.”

Mr Warren says that in most cases, it’s only when fuel is left in the
tank for several months there’s the risk of engine damage. This is much
more likely to occur in cars running dual LPG/petrol systems.

“By this time the fuel will have gone dark and gummy and can clog the
fuel pump, filter and injectors,” Mr Warren says. It can also leave a
lacquer deposit on the inside of the fuel tank which is difficult to remove.

In addition, it’s important to be aware that fuel brews – specifically
fuel volatility - varies on a month to month basis. Standards vary from
state to state but, generally, volatility is reduced during summer
months to reduce evaporative emissions. Mr Whitfield says this
typically makes the engine slightly harder to start but there is no
change in octane.

Lachlan Riddel, proprietor of Gold Coast based tuning company
ChipTorque, frequently dyno tests cars which have not previously been
driven for several weeks.

“On the fuel mix we have in Queensland, I think fuel in a car’s tank is
starting to go off in around three weeks,” Mr Riddel says. “We can tune
a car, put it away for three of four weeks, come back to it and it will
be either closer to detonation or less likely to make the same power.

“I think local fuel is brewed to reduce evaporative emissions in warm
weather and, maybe because of that, fuel really goes crappy in eight to
ten weeks. By that stage, the fuel is extremely prone to detonation.”

Interestingly, Mr Riddel hasn’t noticed the engine becoming harder to start but the effect on octane is pronounced.

Similarly, the General Manager of Melbourne’s Advanced Vehicle
Operations, Steve Coates, believes fuel tends to go off in a car’s fuel
tank quite quickly once it’s a couple of weeks old.

“After a couple of weeks not driving a car, I find that it will be
closer to detonation than it was at the time of tuning on the chassis
dyno,” he says.

“And the brand of fuel seems to make a difference as well – I find that
Mobil and BP products are probably the best after being stored but
Shell Optimax is really good when it’s new."

Clearly, there are some important factors to keep in mind when storing
fuel in a container for several months or when parking your car for a
few weeks.

Our recommendation is not to run the engine at high load with fuel
that’s been in the tank for any more than three of four weeks and it’s
a good idea to add at least 25 percent fresh fuel to the tank every few
weeks. This will help ensure there are no fuel-related driveability
problems or detonation and will reduce the chance of lacquer building
up inside the tank